Biodegradability enhancement of waste lubricating oil regeneration wastewater using electrocoagulation pretreatment.
Biodegradability
Electrocoagulation
Flocs
GC–MS
Pretreatment
Waste lubricating-oil regeneration wastewater
Journal
Environmental science and pollution research international
ISSN: 1614-7499
Titre abrégé: Environ Sci Pollut Res Int
Pays: Germany
ID NLM: 9441769
Informations de publication
Date de publication:
Oct 2023
Oct 2023
Historique:
received:
18
01
2023
accepted:
07
09
2023
medline:
23
10
2023
pubmed:
20
9
2023
entrez:
20
9
2023
Statut:
ppublish
Résumé
As a sustainable management of fossil fuel resources and ecological environment protection, recycling used lubricating oil has received widespread attention. However, large amounts of waste lubricating-oil regeneration wastewater (WLORW) are inevitably produced in the recycling process, and challenges are faced by traditional biological treatment of WLORW. Thus, this study investigated the effectiveness of electrocoagulation (EC) as pretreatment and its removal mechanism. The electrolysis parameters (current density, initial pH, and inter-electrode distance) were considered, and maximal 60.06% of oil removal was achieved at a current density of 15 mA/cm
Identifiants
pubmed: 37728675
doi: 10.1007/s11356-023-29841-7
pii: 10.1007/s11356-023-29841-7
doi:
Substances chimiques
Wastewater
0
Industrial Waste
0
Oils
0
Water Pollutants, Chemical
0
Types de publication
Journal Article
Langues
eng
Sous-ensembles de citation
IM
Pagination
106421-106430Subventions
Organisme : Natural Science Foundation of Jiangxi Province
ID : 20212BAB214006
Organisme : Science and Technology Research Project of Jiangxi Provincial Department of Education
ID : GJJ2200645
Organisme : Science and Technology Research Project of Jiangxi Provincial Department of Education
ID : GJJ2200652
Organisme : Key Research and Development Project of Jiangxi Province
ID : 20203BBG72W007
Organisme : Major Discipline Academic and Technical Leaders Training Program of Jiangxi Province
ID : 20212BBG73017
Informations de copyright
© 2023. The Author(s), under exclusive licence to Springer-Verlag GmbH Germany, part of Springer Nature.
Références
Abdalrhman AS, Zhang Y, El-Din MG (2019) Electro-oxidation by graphite anode for naphthenic acids degradation, biodegradability enhancement and toxicity reduction. Sci Total Environ 671:270–279. https://doi.org/10.1016/j.scitotenv.2019.03.262
doi: 10.1016/j.scitotenv.2019.03.262
Abdulhadi BA, Kot P, Hashim KS, Shaw A, Khaddar RA (2019) Influence of current density and electrodes spacing on reactive red 120 dye removal from dyed water using electrocoagulation/electroflotation (EC/EF) process. IOP Conference Series: Mat Sci Eng 584:012035. https://doi.org/10.1088/1757-899X/584/1/012035
doi: 10.1088/1757-899X/584/1/012035
Adachi Y, Di C, Xiao F, Kobayashi M (2019) Size, orientation, and strength of Na-montmorillonite flocs flowing in a laminar shear flow. Colloid Polym Sci. https://doi.org/10.1007/s00396-019-04532-3
Akhtar A, Aslam Z, Asghar A, Bello MM, Raman AAA (2020) Electrocoagulation of Congo Red dye-containing wastewater: optimization of operational parameters and process mechanism. J Environ Chem Eng 8:10. https://doi.org/10.1016/j.jece.2020.104055
Al-Shannag M, Al-Qodah Z, Bani-Melhem K, Qtaishat MR, Alkasrawi M (2015) Heavy metal ions removal from metal plating wastewater using electrocoagulation: kinetic study and process performance. Chem Eng J 260:749–756. https://doi.org/10.1016/j.cej.2014.09.035
doi: 10.1016/j.cej.2014.09.035
An C, Huang G, Yao Y, Zhao S (2017) Emerging usage of electrocoagulation technology for oil removal from wastewater: a review. Sci Total Environ 579:537–556. https://doi.org/10.1016/j.scitotenv.2016.11.062
doi: 10.1016/j.scitotenv.2016.11.062
Ben Sasson M, Calmano W, Adin A (2009) Iron-oxidation processes in an electroflocculation (electrocoagulation) cell. J Hazard Mater 171:704–709. https://doi.org/10.1016/j.jhazmat.2009.06.057
Coimbra ECL, Mounteer AH, Carmo ALVD, Michielsen MJF, Silva PRD (2021) Electrocoagulation of kraft pulp bleaching filtrates to improve biotreatability. Process Saf Environ Prot 147:346–355. https://doi.org/10.1016/j.psep.2020.09.039
doi: 10.1016/j.psep.2020.09.039
Garcia-Segura S, Eiband MMSG, de Melo JV, Martínez-Huitle CA (2017) Electrocoagulation and advanced electrocoagulation processes: a general review about the fundamentals, emerging applications and its association with other technologies. J Electroanal Chem 801:267–299. https://doi.org/10.1016/j.jelechem.2017.07.047
doi: 10.1016/j.jelechem.2017.07.047
Garfi M (2022) Biological treatment of organic waste in wastewater-towards a circular and bio-based economy. Water 14:2. https://doi.org/10.3390/w14030360
GilPavas E-M-T, Gómez-García K, Ángel M (2009) Treatment of automotive industry oily wastewater by electrocoagulation: statistical optimization of the operational parameters. Water Sci Technol 60:2581–2588. https://doi.org/10.2166/wst.2009.519
doi: 10.2166/wst.2009.519
Gong C, Zhang Z, Li H, Li D, Cheng Y (2014) Electrocoagulation pretreatment of wet-spun acrylic fibers manufacturing wastewater to improve its biodegradability. J Hazard Mater 274C:465–472. https://doi.org/10.1016/j.jhazmat.2014.04.033
Hansen HK, Pena SF, Gutierrez C, Lazo A, Lazo P, Ottosen LM (2019) Selenium removal from petroleum refinery wastewater using an electrocoagulation technique. J Hazard Mater 364:78–81. https://doi.org/10.1016/j.jhazmat.2018.09.090
doi: 10.1016/j.jhazmat.2018.09.090
Harif T, Adin A (2011) Size and structure evolution of kaolin-Al(OH)3 flocs in the electroflocculation process: a study using static light scattering. Water Res 45:6195–6206. https://doi.org/10.1016/j.watres.2011.09.027
doi: 10.1016/j.watres.2011.09.027
Hashim KS, Hussein AH, Zubaidi SL, Kot P, Alwash R (2019) Effect of initial pH value on the removal of reactive black dye from water by electrocoagulation (EC) method. J Physics: Conference Series 1294:072017. https://doi.org/10.1088/1742-6596/1294/7/072017
doi: 10.1088/1742-6596/1294/7/072017
Ingelsson M, Yasri N, Roberts EPL (2020) Electrode passivation, faradaic efficiency, and performance enhancement strategies in electrocoagulation-a review. Water Res 187:25. https://doi.org/10.1016/j.watres.2020.116433
Islam MS, McPhedran KN, Messele SA, Liu Y, El-Dinetc MG (2018) Isotherm and kinetic studies on adsorption of oil sands process-affected water organic compounds using granular activated carbon. Chemosphere 202:716–725. https://doi.org/10.1016/j.chemosphere.2018.03.149
Jimenez C, Saez C, Martinez F, Canizares P, Rodrigo MA (2012) Electrochemical dosing of iron and aluminum in continuous processes: a key step to explain electro-coagulation processes. Sep Purif Technol 98:102–108. https://doi.org/10.1016/j.seppur.2012.07.005
doi: 10.1016/j.seppur.2012.07.005
Jing GG, Ren S, Pooley S, Sun W, Kowalczuk PB, Gao ZY (2021) Electrocoagulation for industrial wastewater treatment: an updated review. Environ Sci-Wat Res Technol 7:1177–1196. https://doi.org/10.1039/d1ew00158b
doi: 10.1039/d1ew00158b
Khani MR, Kuhestani H, Kalankesh LR, Kamarehei B, Rodriguez-Couto S, Baneshi MM, Shahamat YD (2019) Rapid and high purification of olive mill wastewater (OMV) with the combination electrocoagulation-catalytic sonoproxone processes. J Taiwan Inst Chem Eng 97:47–53. https://doi.org/10.1016/j.jtice.2019.02.003
doi: 10.1016/j.jtice.2019.02.003
Li C, Deng W, Gao CJ, Xiang XM, Feng XH, Batchelor B, Li Y (2019) Membrane distillation coupled with a novel two-stage pretreatment process for petrochemical wastewater treatment and reuse. Sep Purif Technol 224:23–32. https://doi.org/10.1016/j.seppur.2019.05.007
doi: 10.1016/j.seppur.2019.05.007
Liu F, Zhang ZX, Wang ZL, Li XQ, Dai XD, Wang LQ, Wang XW, Yuan ZH, Zhang J, Chen MX, Wang S (2019) Experimental study on treatment of tertiary oil recovery wastewater by electrocoagulation. Chem Eng Process 144:8. https://doi.org/10.1016/j.cep.2019.107640
Liu Y, Zhang X, Jiang WM, Wu MR, Li ZH (2021) Comprehensive review of floc growth and structure using electrocoagulation: characterization, measurement, and influencing. Chem Eng J 417:24. https://doi.org/10.1016/j.cej.2021.129310
Lu LA, Ma YS, Kumar M, Lin JG (2011) Photo-Fenton pretreatment of carbofuran—analyses via experimental design, detoxification and biodegradability enhancement. Sep Purif Technol 81:325–331. https://doi.org/10.1016/j.seppur.2011.07.040
doi: 10.1016/j.seppur.2011.07.040
Maceiras R, Alfonsín V, Morales FJ (2016) Recycling of waste engine oil for diesel production. Waste Manage 60:351–356. https://doi.org/10.1016/j.wasman.2016.08.009
Mishra A, Siddiqi H, Kumari U, Behera ID, Mukherjee S, Meikap BC (2021) Pyrolysis of waste lubricating oil/waste motor oil to generate high-grade fuel oil: a comprehensive review. Renew Sust Energ Rev 150:111446. https://doi.org/10.1016/j.rser.2021.111446
Moreira VR, Lebron YAR, Gomes RF, Furtado TDB, Reis BG, Santos LVS, Amaral MCS (2020) Enhancing biodegradability and reducing toxicity of a refinery wastewater through UV/H2O2 pretreatment. J Environ Chem Eng 8:8. https://doi.org/10.1016/j.jece.2020.104442
doi: 10.1016/j.jece.2020.104442
Nasrullah M, Zularisam AW, Krishnan S, Sakinah M, Singh L, Fen YW (2019) High performance electrocoagulation process in treating palm oil mill effluent using high current intensity application. Chin J Chem Eng. https://doi.org/10.1016/j.cjche.2018.07.021
Nasrullah M, Singh L, Krishnan S, Sakinah M, Mahapatra DM, Zularisam AW (2020) Electrocoagulation treatment of raw palm oil mill effluent: effect of operating parameters on floc growth and structure. J Water Process Eng 33:11. https://doi.org/10.1016/j.jwpe.2019.101114
Nawarkar CJ, Salkar VD (2019) Solar powered electrocoagulation system for municipal wastewater treatment. Fuel 237:222–226. https://doi.org/10.1016/j.fuel.2018.09.140
doi: 10.1016/j.fuel.2018.09.140
Pantorlawn W, Threrujirapapong T, Khanitchaidecha W, Channei D, Nakaruk A (2017) Electrocoagulation for spent coolant from machinery industry. J Water Reuse Desalination 8(4):497–506. https://doi.org/10.2166/wrd.2017.057
Pérez LS, Rodriguez OM, Reyna S, Sánchez-Salas JL, Lozada JD, Quiroz MA, Bandala ER (2016) Oil refinery wastewater treatment using coupled electrocoagulation and fixed film biological processes. Phys Chem Earth Parts A/B/C 91:53–60. https://doi.org/10.1016/j.pce.2015.10.018
Robbins CA, Yin Y, Hanson AJ, Blotevogel J, Borch T, Tong T (2022) Mitigating membrane wetting in the treatment of unconventional oil and gas wastewater by membrane distillation: a comparison of pretreatment with omniphobic membrane. J Membrane Sci 645:120198. https://doi.org/10.1016/j.memsci.2021.120198
doi: 10.1016/j.memsci.2021.120198
Safari S, Azadi Aghdam M, Kariminia HR (2015) Electrocoagulation for COD and diesel removal from oily wastewater. Int J Environ Sci Technol 13:231–242. https://doi.org/10.1007/s13762-015-0863-5
doi: 10.1007/s13762-015-0863-5
Shan LL, Liu JF, Ambuchi JJ, Yu YL, Huang LL, Feng YJ (2017) Investigation on decolorization of biologically pretreated cellulosic ethanol wastewater by electrochemical method. Chem Eng J 323:455–464. https://doi.org/10.1016/j.cej.2017.04.121
Shen MC, Zhang YX, Almatrafi E, Hu T, Zhou CY, Song B, Zeng ZT, Zeng GM (2022) Efficient removal of microplastics from wastewater by an electrocoagulation process. Chem Eng J 428:13. https://doi.org/10.1016/j.cej.2021.131161
Shokri A, Fard MS (2022) A critical review in electrocoagulation technology applied for oil removal in industrial wastewater. Chemosphere 288:16. https://doi.org/10.1016/j.chemosphere.2021.132355
Tong K, Lin AG, Ji GD, Wang D, Wang XH (2016) The effects of adsorbing organic pollutants from super heavy oil wastewater by lignite activated coke. J Hazard Mater 308:113–119. https://doi.org/10.1016/j.jhazmat.2016.01.014
doi: 10.1016/j.jhazmat.2016.01.014
Wu Z, Zheng Q, Zhang YB, Pang Y, Huang T, Peng DP (2023) Phosphorus recovery from waste-activated sludge through vivianite crystallization enhanced by magnetic biochar. J Clean Prod 392:10. https://doi.org/10.1016/j.jclepro.2023.136294
Ye H, Chen L, Kou Y, How ZT, El-Din MG (2021) Influences of coagulation pretreatment on the characteristics of crude oil electric desalting wastewaters. Chemosphere 264:128531. https://doi.org/10.1016/j.chemosphere.2020.128531
Zhao C, Zhou J, Yan Y, Yang L, Zheng H (2020) Application of coagulation/flocculation in oily wastewater treatment: a review. Sci The Total Environment 765:142795. https://doi.org/10.1016/j.scitotenv.2020.142795